Safety Recall N336 – Door Will Not Latch – 2016 Land Rover Range Rover & Range Rover Sport

“This site contains affiliate links for which OEMDTC may be compensated”

May 23, 2019 NHTSA CAMPAIGN NUMBER: 19V390000

Left Hand Door May Remain Unlatched and Open

The unlatched door may open while the vehicle is in motion, increasing the risk of injury or a crash.

 

NHTSA Campaign Number: 19V390

Manufacturer Jaguar Land Rover North America, LLC

Components LATCHES/LOCKS/LINKAGES

Potential Number of Units Affected 28,671

 

Summary

Jaguar Land Rover North America, LLC (Land Rover) is recalling certain 2016 Range Rover and Range Rover Sport vehicles. A spring in the Keyless Vehicle Latching System (KV Latch) may get stuck, causing the left hand door to remain unlatched when the door is closed.

 

Remedy

Land Rover will notify owners, and dealers will update the software, and inspect the KV latches, replacing them if necessary, free of charge. The recall began December 6, 2019. Owners may contact Land Rover customer service at 1-800-637-6837. Land Rover’s number for this recall is N336.

 

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

 

Check if your Land Rover has a Recall

 


NOTIFICATION OF SAFETY RECALL N336

NAS19.06.008
ISSUE 2
RECALL USA AFTERSALES BULLETIN
FEBRUARY 12, 2020

 

 

Jaguar Land Rover North America, LLC has informed the National Highway Traffic Safety Administration (NHTSA) of its intent to perform a voluntary Safety Recall on certain 2016 model year Land Rover Range Rover Sport and Range Rover vehicles imported into the United States market. Information relating to this Recall will be posted on the National Highway Traffic Safety Administration website.

United States Federal regulations require that retailers must be notified within a reasonable time after the manufacturer decides that a defect that relates to motor vehicle safety or a noncompliance exists.

United States Federal law requires retailers to complete any outstanding Recall service before a new vehicle is delivered to the buyer or lessee. Violation of this requirement by a retailer could result in a civil penalty of up to $21,780.00 per vehicle.

This Aftersales Bulletin serves as notification to all Land Rover retailers in the United States and Federalized Territories that any affected new vehicles may not be sold and delivered for customer use until the Recall repair is completed.

NOTE: this bulletin updates NAS19.06.008. This bulletin (issue 2) supersedes previous versions; changes are highlighted in blue.

 

DESCRIPTION OF DEFECT

An issue has been identified on certain Land Rover vehicles within the listed Affected Vehicle Range where customers have reported a front and/or rear left door is unlatched when in the closed position and no indication provided of an unlatched condition. Some customers have reported that a front and/or rear door on the left-side of the vehicle has opened while the vehicle was in motion. A spring in the Keyless Vehicle Latching System (KV Latch) may jam between the outside transmission lever and chamfer bush. With the spring trapped, the latch assembly cannot return to its correct position and the latch assembly will not fully latch the door.

 

AFFECTED VEHICLE RANGE

Range Rover Sport (L494)
Model Year:  …………….. 2016
VIN:  …………………………… SALWG2VF0GA556983-SALWR2EF6GA599458
……………………………………. SALWR2VF5GA636516-SALWG2PFXGA657901

Range Rover (L405)
Model Year:  …………….. 2016
VIN:  …………………………… SALGS2EF3GA258138-SALGS2PF8GA298504

A total of 28,671 vehicles are potentially involved in the USA and Federalized Territories. Visit the British Brands Sales Suite (BBSS) website for a list of affected vehicles at your retailer.

 

EFFECT ON VEHICLE OPERATION

Vehicle doors which are not latched in either the primary or secondary state may, while driving, open. This can increase the risk of a vehicle crash or compromise the safety of vehicle occupants.

 

SERVICE PROGRAM / REWORK ACTION

Owners will be notified by mail and instructed to take their vehicle to an authorized retailer who will replace the front and rear left door latch assemblies with one that fully meets the engineering specification.

There will be no charge to owners for this action.

 

OWNER NOTIFICATION

Owner notification is expected to occur on or before July 17, 2019.

 

ACTION TO BE TAKEN

Check DDW to ensure that the vehicle is affected by this Program prior to undertaking any rework action.

Retailers are required to HOLD affected new vehicles that are within your control and refrain from releasing the vehicles for new vehicle sale pending completion of the rework action. Affected vehicles already in the hands of customers should be updated at the next available opportunity.

Jaguar Land Rover North America recommends that affected sales demonstrator and loaner vehicles are repaired before use and that used vehicles are repaired before sale. Retailers who choose to proceed against this recommendation, where legally permitted, must clearly and conspicuously disclose the open recall to the applicable customers.

A Technical Bulletin will be published once repair instructions are finalized and any required parts have been procured.

Thank you for your cooperation in this matter. Jaguar Land Rover North America apologizes for any inconvenience this may cause.

 

PARTS

NOTE: only order the expected percentage demand of parts identified.

Use the Vehicle Identification Number (VIN) and the Electronic Parts Catalog (EPC) to confirm part number(s) necessary to perform repairs.

Range Rover Sport

DESCRIPTION PART
NUMBER
QUANTITY EXPECTED
PERCENTAGE
DEMAND
Front left door latch – With soft close LR078729 1 5%
Front left door latch – Without soft close LR078731 1 5%
Rear left door latch – With soft close LR078749 1 2%
Rear left door latch – Without soft close LR078752 1 2%
Front door – Door trim panel clip LR036935 5 5%
Front door – Door trim panel clip LR013135 11 5%
Rear door – Door trim panel clip LR036935 5 2%
Rear door – Door trim panel clip LR013135 9 2%

 

NOTE: only order the expected percentage demand of parts identified.

Use the Vehicle Identification Number (VIN) and the Electronic Parts Catalog (EPC) to confirm part number(s) necessary to perform repairs.

Range Rover

DESCRIPTION PART
NUMBER
QUANTITY EXPECTED
PERCENTAGE
DEMAND
Front left door latch – With soft close LR078729 1 5%
Front left door latch – Without soft close LR078731 1 5%
Rear left door latch – With soft close LR078749 1 2%
Rear left door latch – Without soft close LR078752 1 2%
Front door – Door trim panel clip LR036935 5 5%
Front door – Door trim panel clip LR013135 10 5%
Rear door – Door trim panel clip LR036935 5 2%
Rear door – Door trim panel clip LR013135 9 2%
Rear door – Door trim panel clip – Long wheelbase vehicles only LR036129 6 2%
Rear door – Door trim panel clip – Long wheelbase vehicles only LR013135 11 2%

 

TOOLS

Refer to the Technical Bulletin referenced above for any required special tools.

 

WARRANTY

NOTE: use the Jaguar Land Rover claims submission system to make sure that a vehicle is eligible for this program prior to undertaking any rework action.

At the time of confirming a booking for vehicle repair, make sure that all outstanding Recall and Service Actions are identified to ensure the correct parts are available and adequate workshop time is allocated for repairs to be completed in one visit.

Warranty claims must be submitted quoting Program Code ‘N336’, Option Code ‘X’, and the relevant SRO and Parts information. The SRO that allows for the drive in/drive out allowance may only be claimed if the vehicle is brought into the workshop for this action alone to be undertaken.

Repair procedures are under constant review and therefore times / prices are subject to change; those quoted here must be taken as guidance only. Use TOPIx to obtain the latest repair time.

Warranty claims must be submitted for payment within 30 calendar days of completion of the repair.

NOTE: the Remote Function Actuator (RFA) may also be referred to as Keyless Vehicle Module (KVM).

PROGRAM
CODE
OPTION
CODE
DESCRIPTION SRO TIME
(HOURS)
N336 X Disable fast unlock/open actuator – Complete application 86.90.84 0.2
N336 X Latch – front door – left hand – renew 76.37.06 0.9
N336 X Latch – rear door – left hand – renew 76.37.07 0.8
N336 X Latch – Pair – Renew 76.37.89.66 1.6
N336 X Drive in/drive out 02.02.02 0.2

 

Normal Warranty policies and procedures apply.

 

CUSTOMER RE-IMBURSEMENT FOR PREVIOUS REPAIRS

If a customer has indicated that they have already paid for this concern as a normal retail repair (vehicle outside normal warranty period), a copy of the repair invoice must be produced as proof of the repair. The retailer must directly reimburse the customer and a claim for recovery of this cost should be made using the related damage procedure.

Supplementary claims for related damages can only be made once the Recall claim has been paid and accepted. Only repairs performed using approved Jaguar parts are eligible for reimbursement.

Submit claims quoting Program Code ‘N336’ and click the ‘Related Damage’ radio button on the claim submission screen. Use Option Code ‘X’ as detailed below and enter the cost to be reimbursed against the sundry code of ‘ZZZ999’. All costs are to be entered in local currency.

PROGRAM
CODE
OPTION
CODE
DESCRIPTION TIME
(HOURS)
SUNDRY
CODE
MISCELLANEOUS
EXPENSE ($)
N336 X Re-imbursement to owner N/A ZZZ999 Retailer Entered Value

 

A copy of the invoice must be appended to the repair order for Warranty Audit purposes and Warranty Specialist review. Enter a brief comment in the ‘Technician Comments’ field on the claim to itemize and explain the charges.

Only vehicles eligible for this Safety Recall are included in this process. Only one claim per vehicle for related damages will be accepted.


TECHNICAL Q & A: SAFETY RECALL N336

 

Main Message: An issue has been identified on certain 2016MY Range Rover Sport and Range Rover with passive entry system where reports of left front or rear door being unlatched when thought to be in the closed position and no indication provided of an unlatched condition.

Q1 Who do I contact if a member of the press contacts me about this recall?

A Please ensure Press enquiries are referred to the Jaguar Land Rover North America Press Office to the attention of:

Stuart Schorr
Vice President, Communications & Public Affairs
Jaguar Land Rover North America, LLC
sschorr@jaguarlandrover.com
Office: +1-201-760-8561
Cell: +1-201-739-2964

 

Q2 Why is Jaguar Land Rover recalling certain Land Rover vehicles? 

A A concern has been identified on certain 2016MY Land Rover Range Rover Sport and Range Rover vehicles where customers have reported a front or rear left door is unlatched when in the closed position and no indication provided of an unlatched condition. Some customers have reported that a door on the left of the vehicle has opened while the vehicle was in motion. The Keyless Vehicle mechanism which forms part of the door latch system can become jammed. In a jammed condition, the Keyless Vehicle mechanism does not permit the latch assembly to return to its correct position so allowing the latch claw to rotate freely.

Vehicle doors not latched in either the primary of secondary state may, during driving, open. This can increase the risk of a vehicle crash or compromise the safety of vehicle occupants.

 

Q3 Can you tell me more about what is wrong with the vehicles?

A An investigation was opened following an Engineering Analysis request from the National Highway Traffic Safety Administration (NHTSA) to review reports of unlatched doors whilst in motion on vehicles outside of the previous P068 recall Vehicle Identification Number (VIN) range. The investigation was conducted to understand the nature of the error state and the scope of the issue. Discussions with the door latch supplier were held in regards potential issues which may impact the ability of the Unilatch Keyless Vehicle door latch to correctly operate. Data analysis indicated a pattern and trend for doors not latching on the left of the vehicle for a discreet population of vehicles manufactured from October 1, 2015 to May 27, 2016.

From component analysis conducted with the supplier it was revealed that the front and rear left door latch outside transmission lever and bush chamfer components within the Keyless Vehicle mechanism were not manufactured to the designed dimensional specifications and tolerances. With use, over time a return spring in the Keyless Vehicle mechanism can get trapped so jamming the Keyless Vehicle mechanism in the door unlatch state.

Where left door latches contain both out of specification transmission lever and bush chamfer components, there is a risk that over time the defect will occur.

 

Q4 How would the customer become aware of potentially having this concern?

A Customers may notice the front or rear left doors of the vehicle may not latch in either the primary or secondary state and bounce back when push closed.

 

Q5 Does this concern affect vehicle safety?

A Vehicle doors not latched in either the primary of secondary state may, during driving, open. This can increase the risk of a vehicle crash or compromise the safety of vehicle occupants.

 

Q6 Has Jaguar Land Rover Limited received many complaints?

A Yes, there have been reports of this issue.

 

Q7 Have there been any accidents or injuries?

A Jaguar Land Rover is not aware of any accidents or injuries which have been attributed to this issue.

 

Q8 How was the condition discovered?

A An Engineering Analysis was issued from the US National Highway Traffic Safety Administration (NHTSA) to review in detail reports of unlatched doors whilst in motion for vehicles outside of the P068 recall VIN range.

 

Q9 How long has Jaguar Land Rover known about this problem?

A NHTSA issued their Inquiry Letter March 26, 2019.

 

Q10 Is the defect leading you to any concerns regarding the reliability of a system, which is supposed to be designed and engineered for the passengers’ safety? What type of measures are you planning to take?

A We have no concerns with the overall reliability of the vehicle. Jaguar Land Rover carefully monitors field data to ensure that any matters relating to safety and compliance are rigorously investigated.

 

Q11 What has Jaguar Land Rover done in production?

A Production vehicles are manufactured with assured quality door latches.

 

Q12 What will an authorized Land Rover retailer do to the vehicles?

A An authorized retailer who will install software that will disable the Unilatch Keyless Vehicle entry function on the vehicle. After the latest software update is applied, a check of the Keyless Vehicle entry function mechanism on the left front and left rear door latches will be performed to determine if the mechanism freely operates. If free operation is not detected, the malfunctioning left door latch assembly will be replaced with a new latch.

 

Q13 Which vehicles are affected by this recall?

A Range Rover Sport (L494)
Model Year:  …………….  2016
VIN:  ……………………………  SALWG2VF0GA556983-SALWR2EF6GA599458
…………………………………….  SALWR2VF5GA636516-SALWG2PFXGA657901

Range Rover (L405)
Model Year:  …………….  2016
VIN:  ……………………………  SALGS2EF3GA258138-SALGS2PF8GA298504

 

Q14 Are other Jaguar Land Rover models affected by these actions?

A No other models, other than those listed on this document, are known to be affected by this condition.

 

Q15 Are parts available to rework vehicles?

A Yes, the necessary software and parts are available for authorized Land Rover retailers to conduct this repair.

 

Q16 How much will the recall cost Jaguar Land Rover?

A Cost was not a factor in deciding to recall these vehicles.

 

Q17 How do I know if my vehicle is affected?

A All owners of potentially affected vehicles will shortly receive a letter inviting them to contact an authorized Land Rover retailer for the work to be carried out.

 

Q18 How long does it take for the vehicle to be inspected and repaired?

A The work will be carried out as quickly and efficiently as possible to minimize inconvenience to customers and is expected to take no longer than two (2) hours. Due to retailer schedules, vehicles may be required for longer.

 

Q19 Can I continue to drive my vehicle safely until it has been recalled?

A Customers are advised to contact an authorized Land Rover retailer should they have any concerns regarding their vehicles.

Customers are advised that until your vehicle is repaired, Jaguar Land Rover strongly recommend that all vehicle occupants are secured using the vehicle seat belts, ensure all doors are fully latched/closed, and check the instrument cluster for any ‘door ajar’ warnings before you drive away. Contact an authorized Land Rover retailer if they have any concerns regarding their vehicles.


2016 MY RANGE ROVER RANGE ROVER SPORT

Safety Recall N336 – Doors may not latch or open while driving

  • A spring in the Keyless Vehicle Latching System (KV Latch) may jam between the outside transmission lever and chamfer bush. With the spring trapped, the latch assembly cannot return to its correct position and the latch assembly will not fully latch the door. Vehicle doors not latched in either the primary of secondary state may open during driving.
  • Land Rover approved repairers will replace both left hand side door latches with assemblies that fully meets the engineering specification.
  • 28,679 USA vehicles are affected. Does not affect Canada.
  • Retailers were notified by Bulletin on June 6th 2019
  • The date for availability of parts and the repair bulletin is being actively managed with the supplier. A review on June 19th is expected to provide a timing plan. Retailers will be updated as soon as this information becomes available.
  • Customer mailing notification by July 19th
  • All affected new vehicles have been retailed.

573.6 (c) (6) – Chronology of Events

A Product Safety and Compliance Committee (PSCC) investigation was opened on March 26, 2019, following an investigation by the Product Compliance external investigations team, who had received an Engineering Analysis request from National Highway Traffic Safety Administration (NHTSA) to review claims of door unlatched outside of the previous P068 recall VIN range.

A Jaguar Land Rover Engineering investigation was conducted to understand the nature of the failure mode and the scope of the issue.

During the investigation in April, 2019, the engineering team reviewed all available data including assessment of field return components. The engineering team conducting ongoing discussion with the door latch supplier in regards to the prior investigation and other potential issues which may impact the ability of the Unilatch Keyless Vehicle (KV) door latch to correctly operate.

In late April, 2019, detailed analysis of reports relating to vehicles manufactured after the cut off point for the P068 recall campaign where reports similar to those in the P068 recall campaign were received. This detailed analysis engendered a detailed assessment of the post-P068 vehicle population and the causes of the post-P068 recall failures.

During the investigation in late April and early May, 2019, the data analysis indicated a pattern and trend for doors not latching on the left hand side of the vehicle for a discreet population manufactured within the date range specified. Investigations revealed from component analysis conducted with the supplier revealed that the left hand side door latch outside transmission lever and bush chamfer components were not manufactured to the designed dimensional specifications.

Where left hand side latches contain both out of specification transmission level and bush chamfer components, there is a risk that over time the defect will occur. Analysis conducted by the supplier showed that these out of specification parts were supplied to Jaguar Land Rover during the period specified. There is an elevated report rate for vehicles manufactured during the affected period.

Engineering concluded on May 14, 2019, that vehicles with left hand latch assemblies fitted with out of specification components could prevent the left hand side front or rear door from latching correctly.

The PSCC reviewed the scope of the issue and concluded that this issue be progressed to the Jaguar Land Rover Recall Determination Committee (RDC) for consideration.

The RDC reviewed the concern on May 16, 2019, and concluded that the concern represented an unreasonable risk to safety and that a voluntarily safety recall be conducted.

There have been no reported accidents or injuries as a result of this concern.


 


2 Affected Products

Vehicles

MAKE MODEL YEAR
LAND ROVER RANGE ROVER 2016
LAND ROVER RANGE ROVER SPORT 2016

 


30 Associated Documents

Recall Acknowledgement

RCAK-19V390-5588.pdf 483.711KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [472.37 KB]

 


Chronology

RMISC-19V390-7806.pdf 7.846KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [7.66 KB]

 


Defect Notice 573 Report

RCLRPT-19V390-5956.PDF 214.304KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [209.28 KB]

 


Manufacturer Notices(to Dealers,etc) – NOTIFICATION OF SAFETY RECALL N336

RCMN-19V390-3875.pdf 135.379KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [132.21 KB]

 


Miscellaneous Document – Safety Recall 19V390 – N336 – June 2019 Conference Call Slide 9

RMISC-19V390-0341.pdf 20.542KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [20.06 KB]

 


Remedy Instructions and TSB

RCRIT-19V390-7550.pdf 316.548KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [309.13 KB]

 


Miscellaneous Document – Safety Recall Launch Status N336 – N335 VEHICLE DOOR MAY NOT LATCH

RMISC-19V390-4087.pdf 29.156KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [28.47 KB]

 


Miscellaneous Document – Safety Recall N336NAS1 CARE POINTS Slide

RMISC-19V390-4713.pdf 488.593KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [477.14 KB]

 


Remedy Instructions and TSB

RCRIT-19V390-0596.pdf 439.056KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [428.77 KB]

 


Miscellaneous Document – SAFETY RECALL N336 (NHTSA 19V-390) – DOOR WILL NOT LATCH

RMISC-19V390-9154.pdf 175.884KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [171.76 KB]

 


Recall Quarterly Report #1, 2019-4

RCLQRT-19V390-1808.PDF 211.153KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [206.20 KB]

 


Miscellaneous Document – Safety Recall Launch Status Slide

RMISC-19V390-6764.pdf 28.381KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [27.72 KB]

 


Miscellaneous Document – SAFETY RECALL LAUNCH STATUS Slide

RMISC-19V390-3079.pdf 37.019KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [36.15 KB]

 


SAFETY RECALL LAUNCH STATUS N336 & NEW RECALL N367

RMISC-19V390-2127.pdf 27.372KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [26.73 KB]

 


Miscellaneous Document – Dealer Notification

RMISC-19V390-7425.pdf 85.161KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [83.17 KB]

 


Miscellaneous Document – SAFETY RECALL LAUNCH STATUS N333 DOORS MAY NOT LATCH

RMISC-19V390-2913.pdf 27.347KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [26.71 KB]

 


Miscellaneous Document – USA Market Recall Launch Status Information

RMISC-19V390-7682.pdf 52.24KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [51.02 KB]

 


Miscellaneous Document – Safety Recall Launch Status

RMISC-19V390-7105.pdf 27.305KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [26.67 KB]

 


Miscellaneous Document – Aftersales Bulletin re DOOR WILL NOT LATCH

RMISC-19V390-4272.pdf 164.696KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [160.84 KB]

 


Miscellaneous Document – Safety Recall Launch Status re Door May Not Latch

RMISC-19V390-1926.pdf 92.653KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [90.48 KB]

 


Miscellaneous Document – SAFETY RECALL N336 LAUNCH CARE POINTS

RMISC-19V390-0312.pdf 4536.527KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [4.33 MB]

 


Miscellaneous Document – Webinar reminder email

RMISC-19V390-3546.pdf 93.884KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [91.68 KB]

 


Miscellaneous Document – SAFETY RECALL LAUNCH STATUS

RMISC-19V390-4939.pdf 60.991KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [59.56 KB]

 


Miscellaneous Document – Jaguar Land Rover North America Shop Foreman N336 Webinar – Friday, November 22, 2019

RMISC-19V390-6887.pdf 186.518KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [182.15 KB]

 


ISSUED Owner Notification Letter(Part 577)- English

RCONL-19V390-0526.pdf 314.406KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [307.04 KB]

 


ISSUED Interim Owner Notification Letter(Part 577)

RIONL-19V390-6324.pdf 175.85KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [171.73 KB]

 


ISSUED Interim Owner Notification Letter(Part 577)- Spanish

RIONL-19V390-8378.pdf 177.244KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [173.09 KB]

 


ISSUED Owner Notification Letter(Part 577)- Spanish

RCONL-19V390-3980.pdf 319.964KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [312.46 KB]

 


Miscellaneous Document – SAFETY RECALL LAUNCH STATUS

RMISC-19V390-9639.pdf 98.964KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [96.64 KB]

 


Recall 573 Report – Amendment 1

RCLRPT-19V390-2893.PDF 214.474KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [209.45 KB]

 


Latest Recalls Documents

For the Latest and Most Recent Recalls Information Visit the link below…

https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=19V390&docType=RCL

 


1 Associated Investigation

Door Latch Open While Driving
NHTSA ID: EA18004
Dated opened: July 2, 2018

On June 11, 2015, Jaguar-Land Rover (JLR) submitted a Defect Information Report (DIR) to NHTSA describing a defect condition in the electronically controlled door latch systems of approximately 65,372 model year (MY) 2013-2016 Range Rover and MY 2014-2016 Range Rover Sport that may result in incidents of door opening while driving (NHTSA Recall No. 15V-385, JLR Recall P068).

On August 4, 2017, the Office of Defects Investigation (ODI) opened Recall Query RQ17-005 to investigate claims of doors failing to latch and/or inadvertently opening while driving (latch malfunctions) on MY 2013-2016 Range Rover and MY 2014-2016 Range Rover Sport vehicles that had received the remedy for 15V-385 or were built after the recall remedy had been implemented in production (the subject vehicles). ODI has received 5 unique reports (VOQs) related to the alleged defect in the subject vehicles. All five VOQs allege experiencing at least one incident of a door opening inadvertently while the vehicle was in motion and were repaired by replacing the malfunctioning latch assembly. One minor injury was reported where the consumer did not seek medical care.

ODI’s analysis of information provided by JLR in response to the Information Request (IR) letter for RQ17-005 identified 43 additional complaints and field reports related to door latch malfunctions in the subject vehicles, including 14 additional allegations that a door opened while the vehicle was in motion. In addition, ODI’s analysis of JLR warranty claim data provided in the IR response identified an additional 564 vehicles that received latch replacements to address customer concerns with latch malfunctions, including 72 additional incidents of doors opening while in motion based on ODI’s analysis of customer concern narratives.

ODI is upgrading this investigation to an Engineering Analysis (EA) to further assess the recall remedy, scope, and frequency. See attached pages for additional information.


 

 

Bestseller No. 1
Nu Finish Car Polish, NF-76 Liquid Polish for Cars, Trucks, 16 Fl Oz Each
  • Nu Finish Liquid Car Polish keeps your car exterior looking new with only one application per year.Fit Type: Universal
  • Delivers impressive shine and protection without rubbing or buffing
  • As the only polish available with no wax, the Nu Finish formula is specifically made to protect your car’s paint and clear-coat finish
  • Perfect for use on cars, fiberglass boats, RVs, and even chrome surfaces
  • Apply polish with a damp cloth, let dry to a haze, and wipe off
Bestseller No. 2
Meguiar's M20508 Mirror Glaze Ultra Finishing Polish – 8 Oz Bottle
  • EXCEPTIONAL RESULTS: Advanced technology formula provides a deep gloss and rich, swirl-free results
  • NO MORE SWIRLS: Permanently removes swirls and light defects from all paint
  • STUNNING SHINE: Produces deep reflections and high gloss
  • EASY TO USE: Smooth buffing feel, easy wipe-off, and fast clean-up
  • MULTIPLE WAYS TO APPLY: Formulated for use by Hand, DA Polisher, or Rotary Buffer
Bestseller No. 3
Meguiar's Ultimate Compound, Car Compound Restores Car Paint and Car Shine - 15.2 Fl Oz Bottle
  • REMOVE PAINT DEFECTS: The ultimate product for removing oxidation, scratches, water spots, and blemishes without scratching
  • BEST CAR SCRATCH REMOVER: Cuts as fast as harsh abrasives restoring surface clarity without scratching or swirling
  • SAVES TIME: The clear coat safe formula dramatically reduces the time and effort to restore abused or neglected paint finishes
  • STUNNING FINISH: Exclusive micro-abrasive technology leaves a "like new" finish and adds gloss in one easy step
  • SAFE FOR CLEAR COAT: Safe and effective on clear coat and single stage paints, and can be applied by hand or dual action polisher like Meguiar's MT300 Dual Action Polisher
SaleBestseller No. 4
SHINE ARMOR Ceramic Coating Fortify Quick Coat Car Wax Polish Spray Waterless Wash & Wax Hydrophobic Top Coat Polish & Polymer Paint Sealant Detail Protection 8 Fl Oz
  • Advanced Formula 3-in-1. Our fortify quick coat is your all-in-one ceramic coating hydrophobic spray. Shine Armor Fortify Quick Coat ceramic car wax provides a waterless wash, coat, and shine, all-in-one convenient product.
  • No Streaking, Smearing Or Scratching. Shine Armor Fortify Quick Coat premium formula ceramic car coating is a gentle and effective car polish for any vehicle! Get a clean, shiny finish without hurting your car's paint.
  • Cuts Dirt, Grime & Grease. Our Quick Coat ceramic wax car sealant eliminates dirt, grime & grease instantly! Our signature 3-in-1 formula gives you a waterless car wash, coat and shine for a clean, showcase look.
  • Safe For All Surfaces. Use this car wax spray-on automobiles, boats, motorbikes, RVs, four-wheelers and more! This spray wax is the perfect blend of surfactants and SiO2 ceramic-coating science.
  • Superior Products. This means superior shine for your cars! Our ceramic quick coat also works as a sealer to give your vehicle a clear shield of protection while also providing a beautiful gloss. Our ceramic coat is the best hydrophobic car spray available!
Bestseller No. 5
Turtle Wax T-241A Polishing Compound & Scratch Remover - 10.5 oz. , White
  • Heavy duty paste that cleans dull, oxidized finishes
  • Quickly and easily penetrates through the oxidized surface to remove scratches, blemishes and stubborn stains
  • Restores faded finishes
  • Recommended for rubbing down between coats of newly sprayed lacquer and acrylic car finishes
  • Easy to use formula
SaleBestseller No. 6
Chemical Guys GAP11716 P4 Precision Paint Perfection Polish (Paint Correction - Fixes Scratches, Swirls & Towel Marks), 16 oz.
  • EASY-TO-USE ONE STEP POLISH! - P4 Precision Paint Perfection Polish is the easy-to-use one step polish that removes fine swirls, scratches, towel marks, and corrects 2000 grit and finer sanding marks while leaving virtually no dusting or residue behind! .Fit Type: Universal Fit
  • SAFE FOR ALL PAINTS! - Ultra-fine abrasives used in P4 are specially developed for all paints including ceramic coated vehicles to remove microscopic amounts of clear coat quickly and leave paint incredibly glossy, shiny, and haze-free!
  • WORKS GREAT ON CERAMIC COATINGS! - P4 works great on ceramic coated cars to remove minor imperfections while maintaining the integrity of your coating to produce deep, rich reflections without damaging your protection!
  • SHOW CAR SHINE & GLOSS! - Chemical Guys P4 gently removes fine swirls and scratches to deliver a truly perfect finish with a deep gloss and mirror-like finish as the final step in your polish! For even more comprehensive results, first apply C4 Clear Cut Correction Compound!
  • PERFECT PREP FOR CERAMIC, SEALANT, AND WAX! - Prepping your car with P4 Polish ensures that your wax, sealant, or ceramic coating makes contact with a totally bare surface, maximizing coating adhesion and durability! Get a deep gloss and shine in no time!
SaleBestseller No. 7
CERAKOTE® Rapid Ceramic Paint Sealant (12 oz.) – Now 50% More With a Premium Sprayer! - Maximum Gloss & Shine – Extremely Hydrophobic – Unmatched Slickness - Pro Results
  • UNSURPASSED SLICKNESS – You simply have to touch it to believe how slick this finish is
  • MAXIMUM GLOSS AND SHINE – Hands down the highest level of gloss and shine you will ever experience; Achieve mirror-like results in a simple application, right in your own driveway
  • EXTREMELY HYDROPHOBIC – Cerakote's true ceramic technology repels water, road grime, mud and dirt making your car stay cleaner, longer!
  • QUICK AND EASY TO APPLY - Simply wash and dry your vehicle as you normally would; Then evenly spray a light coat directly to a panel or small area of your vehicle;, then, just lightly buff the coating to an incredible shine! It really doesn't get any easier than this!
Bestseller No. 8
3D Speed Car Scratch Remover Polish & Wax – 16oz – All-In-One Scratch Remover, Swirl Correction & Wax Sealant Protection with Glossy Shine
  • CORRECT & PROTECT … 3D Speed is a premium all in one clear coat car polish & wax all in one bottle!
  • BRING YOUR PAINT BACK TO LIFE … 3D Speed is an excellent scratch and swirl remover polish and sealant that deliver minor paint correction for small or large surface areas! Please note: Our products will not remove deep scratches or correct areas where paint may be missing.
  • DEPTH AND GLOSS IN ONE … Restore your paint's color, depth and gloss while also adding a long lasting wax layer protection to the surface!
  • EASY APPLICATION … You can easily apply 3D Speed by hand for smaller surface areas or with a polisher or buffer for larger areas with more imperfections.
  • PROUDLY MADE IN THE USA ... We've been researching and creating exterior and interior car care products for over 25 years now. A quarter of a century of giving our customers uncompromising quality. Go ahead, experience a car polish and wax that's tried and trusted. Date on bottles reflect manufactured dates, not expiry dates.
SaleBestseller No. 9
Meguiar's Professional Fine-Cut Cleaner M0216 - Pro Mild Abrasive Polish to Remove Light Scratches, Swirls, Water Spots and Stains - Remove Defects and Restore Shine with Diminishing Abrasives, 16 Oz
  • DEFECT REMOVAL: Removes fine surface defects including light oxidation, stains, scratches, swirls and fresh water spots
  • PAINT CLEANER: Mildly abrasive cleaner cuts quickly, then reduces to a buffing rouge, leaving a professional finish ready for polishing and protecting
  • NO SCOURING: Buffered abrasive action lubricates the finish to prevent scouring or scratching
  • CLEAR COAT SAFE: Safe and effective on all glossy paint finishes including clear coats, and especially ideal for older lacquer and enamel paints
  • VERSATILE USE: Body shop safe formula can be used by hand, DA polisher or rotary buffer
Bestseller No. 10
Meguiar's Professional Ultra Pro Finishing Polish M21032 - Achieve a Mirror-Like Finish on Your Car - Remove Swirls and Holograms While Increasing Gloss and Shine, 32 Oz
  • Our best finishing and highest gloss pro polish ever!
  • Creates deep, glossy finish without swirls or holograms
  • Pro cleaner polish designed to remove DA haze or Rotary swirls and leave a flawless finish
  • Easy wipe-off, virtually zero dusting or sling with Rotary or DA Polisher
  • Engineered for flawless finish after Meguiar's M110 Ultra Pro Speed Compound even on dark & sensitive paints

Last update on 2024-03-03 / Affiliate links / Images from Amazon Product Advertising API

This product presentation was made with AAWP plugin.

Leave a Comment

Share to...